Laserfiche WebLink
GENERAL ORDER OF APPROVAL APPLICABILITY WORKSHEET <br /> AUTOMOTIVE REFINISHING OPERATION SPRAY BOOTH <br /> ---�-''` `"'''`�• Puget Sound Clean Air Agency <br /> p s c l e a n a i r.O r g 1904 3rd Avenue, Suite 105, Seattle WA 98101 <br /> Puget Sound Clean Air Agency Telephone: 206-343-8800; Fax: 206-343-7522 <br /> <www.psclea n a i r.o rg> <br /> 1)S Yes ❑ No Is the spray booth commercially manufactured and will it be used only for <br /> automotive refinishing work? <br /> 2) IS Yes El No Will the spray booth be installed inside an approved building? <br /> 3) m Yes ❑ No Will the spray booth be installed in a location where spray coating is an allowed <br /> use in accordance with local Building Department (zoned properly)? <br /> 4) 1 Yes ❑ No Will all spray guns be either high-volume low-pressure(HVLP)or electrostatic? <br /> 5) IS1 Yes ❑ No Will the use of coatings and solvents at this booth be less than 700 gallons in any <br /> 12 consecutive month period? <br /> 6) ❑Yes ❑ No Will the exhaust stack be 6 feet or more above the highest point of the roof? <br /> 7) Yes ❑ No Will the stack exhaust vertically, without obstruction? <br /> 8)SI Yes ❑ No Will the exhaust filters be at least 98% efficient at removing particulate? <br /> 9) IS Yes ❑ No Will the spray booth be equipped with manometer or magnehelic to measure <br /> pressure drop across exhaust filters? <br /> 10) DYes ❑ No Will gun cleaning be done in an enclosed cleaner or by disassembling the guns <br /> and cleaning gun parts in a bucket? <br /> 11) lYes ❑ No Coatings will not contain chromium, cadmium, or lead. (Review MSDS or <br /> contact manufacturer to find answer) <br /> 12) ®Yes ❑ No Are facility-wide potential emissions below Title V source levels? (See <br /> Regulation I,Article 7, http://www.pscleanair.org/regulated/reg1/reg1.pdf) <br /> 13) JYes ❑ No If spray coating takes place inside a prep station, the prep station must be <br /> treated as a spray booth. If you spray coat in a prep station,will you apply for a <br /> separate General Order for the prep station? <br /> Review the answers to questions 1-13. If ALL answers are YES, the spray booth is eligible for coverage <br /> under the General Order. To apply for the General Order, please fill out the General Order of Approval <br /> Application Form (page 2)and submit the application form, this worksheet, and a$500 review fee to the <br /> Puget Sound Clean Air Agency. <br /> If ANY of the answers to questions 1-13 are NO, then the spray booth is NOT eligible for coverage under <br /> the General Order. Please submit a Notice of Construction application for case-by-case permit review per <br /> Agency Regulation I Section 6.03. <br /> Form 50-199(7/9/14 ns) Page 1 of 2 <br />