3003 W CASINO RD 2021 BLDG 40-51 Plans 2023-01-25 (2)

Permit#: PW2105-018 Site Address: 3003 W CASINO RD i--51 BOEING EVERETT FACILITI Owner: BOEING COMPANY Tenant: [Tenli App= Date: 5/10/2021 Proposed Use: MANUF. Description: INSTALL DOUBLE WALL CONTAINMENT PIPE FROM BLDG 40-51 Reviewed BY // Date: e112__ _dOffice Set Job Site Set Fire/Planning Set APPROVED PUBLICOM NT BY SAT t CITY OF EVERETT REVIEWED FOR PERMIT LOCATION MAP I SITE MAP I SCOPE OF WORK i CODE SUMMARY SYMI I REVISION I BY A I PIW UPGRADES ADDENDUM C - DCN-01 208084681 KJ THIS PROJECT INCLUDES, BUT IS NOT LIMITED TO, THE FOLLOWING: DESCRIPTION: INSTALLATION OF NEW AND REPLACEMENT OF ® PROVIDE AND INSTALL APPROXIMATELY 2800 FEET OF NEW PUMPED INDUSTRIAL WASTE EXISTING PROCESS PIPING, ADDITION OF COVERED (PIW) 4—INCH X 6—INCH SCHEDULE 10 STAINLESS STEEL X SCHEDULE 10 STAINLESS TRENCHES. ADDITION OF NEW LEAK DETECTORS. STEEL DOUBLE —CONTAINED PIPING OUTSIDE THE 40-51 BUILDING IN VAULT N4 OF APPLICABLE BUILDING CODES: 2018 INTERNATIONAL BUILDING CODE AS ADOPTED STEAM/UTILITY TUNNEL TO POINT OF CONNECTION (P.O.C.) NORTH OF BRIDGE AND AND AMENDED BY THE CITY OF EVERETT AND P.O.C. SOUTH OF BRIDGE TO STEAM/UTILITY TUNNEL TO 45-06 WATER TREATMENT WASHINGTON STATE PLANT (WTP) AND TANK FARM. a RELOCATE/REPLACE EXISTING UTILITIES, INCLUDING BUT NOT LIMITED TO STORMWATER 2010 INTERNATIONAL MECHANICAL CODE CATCH BASINS AND PIPING, AS MAY BE DESCRIBED IN CONTRACT DOCUMENTS AND NECESSARY FOR THE INSTALLATION OF NEW PIPING AND TRENCHES. 2018 INTERNATIONAL FIRE CODE ® INSTALL NEW ASPHALT PAVING CITY OF EVERETT DESIGN AND CONSTRUCTION INSTALL NEW AND REPLACE EXISTING PIPE SUPPORTS STANDARDS FOR DEVELOPMENT, REV. JANUARY PROVIDE AND INSTALL NEW ELECTRIC HEAT TRACING AND INSULATION ON THE PIW 2018. PIPING, VALVES AND APPURTENANCES OUTSIDE OF THE UTILIDORS AND TRENCHES NFPA 30 FLAMMABLE AND COMBUSTIBLE LIQUIDS ® PROVIDE AND INSTAL ISOLATION AND CHECK VALVES AS SHOWN IN THE DRAWING SET CODE, AS REFERENCED BY THE 2015 IFC. ® PROVIDE AND INSTALL NEW LEAK DETECTION DEVICES, SIGNAL WIRING AND ASSOCIATED PANELS FOR A COMPLETE AND OPERABLE SYSTEM B31.3 PROCESS PIPING AS REFERENCED BY NFPA a PROVIDE ASSOCIATED ELECTRICAL AND CONTROL CONDUIT, WIRING AND DEVICES FOR A 30 AND THE 2015 IFC. COMPLETE AND OPERABLE SYSTEM. o PROVIDE RECOATING/REPAINTING OF DEVICES, PIPING, CONCRETE, STEEL, SUPPORTS, SEE STRUCTURAL NOTES SHEET FOR ADDITIONALCODES REFERENCED, AND OTHER EXISTING APPURTENANCES AFFECTED BY THE WORK. ® REMOVE OR DEMOLISH MISCELLANEOUS EXISTING WORK, AS DESCRIBED IN THE FLUID NOTES: CLASS 1110 COMBUSTIBLE FLUID; WATER THAT CONTRACT DOCUMENTS CONTAINS < 1 KETONE SOLVENTS AND SOME ® PROVIDE OTHER GENERAL WORK ASSOCIATED WITH THIS CONTRACT (CLEANING, SOLIDS° T B31.3 FLUID CATEGORY: NORMAL SCOPE REDUCTION. REMOVAL OF PIW 0600 AND ABANDONED LINE AND INSTALLATION OF NEW PIW 0000 FROM MANHOLE F TO TH PIPING NOTES: PIPING OUTSIDE OF EXISTING CONTAINMENT AREAS WALL WILL BE PERFORMED BY OTHERS. IS DOUBLE CONTAINED (SCHD. 10S CARRIER X SCHD 10S CONTAINMENT) WITH LEAK DETECTION, SUPPORT AND DESIGN PER IMC, MSS®SP—SB, AND B31.3 (WHICHEVER IS MORE RESTRICTIVE). HYDROSTATIC TESTING PER B31.3 TO 225PSIG. CONTROLS AND INTERLOCKS: THE EXISTING SYSTEM HAS AUTOMATED SWITCH —OVER TO THE NEXT SYSTEM HOLDING TANK IF THE FIRST TANK BECOMES FULL, NO CHANGE TO THIS AUTOMATION TO PREVENT OVERFILL IS PLANNED FOR THIS WORK. Lzm� APRIL 20, 1 ROM DRAWN DATE SUBTITLE ACCEPTABILITY D. HOFFER 02.22.21 COVER SHEET THIS DESIGN AND/OR CHECKED — -- - SPECIFICATION IS APPROVED J. FISHER -- 02.22.211 TITLE PUMPED - INDUSTRIAL T APPROVED BY DEPT. DATEE UPGRADES J. FISHER 0Z22.21 CHECKED D. WD ---02.22.21 APPROVED - --- ,APPROVED —- (DISCIPLINE) MASTER 11 Jill 11 g