Laserfiche WebLink
FLASH LOG ••• U N I R FLASH LOG ••• UNIRACLUNSTRUM <br /> �� �� 408 ESTATE DRIVE. <br /> BETTER SOLAR STARTS HERE INSTALLATION GUIDE BETTER SOLAR STARTS HERE JACKSONVILLE,NC 28540-5129 <br /> REVISIONS <br /> DESCRIPTION DATE REV <br /> FLASHLOC is the ultimate attachment for composition shingle and rolled comp roofs.The all-in-one mount installs REDESIGN 05/0512023 A <br /> PRE-INSTALL REDESIGN 07/14/2023 B <br /> fast — no kneeling on hot roofs to install flashing, no prying or cutting shingles, no pulling nails. Simply drive the Snap chalk lines for attachment rows.On shingle roofs,snap lines 1-3/4"below upslope edge <br /> lag bolt and inject sealant into the base. FLASHLOC's patented TRIPLE SEAL technology preserves the roof and of shingle course.Locate rafters and mark attachment locations. Signature with Seal <br /> J i 1.75- <br /> protects the penetration with a permanent pressure seal. Kitted with lag bolts,sealant,and hardware for maximum i At each location,drill a 7/32"pilot hole.Clean roof surface of dirt,debris,snow,and ice, <br /> convenience. Don't just divert water, LOC it out! then fill pilot hole with sealant. <br /> NOTE:Space mounts per racking system install specifications.When down pressure is>_34 psf. <br /> span may not exceed 2 ft. <br /> DATE:01/05/2023 <br /> °UNIRAC PROJECT NAME&ADDRESS <br /> 25 ,_••:.., STEP 1: SECURE <br /> YEn •• Place FLASHLOC over pilot hole with lag on down-slope side.Align indicator marks on sides of <br /> H mount with chalk line.Pass included lag bolt and sealing washer through FLASHLOC into pilot <br /> fUILSYSITM hole.Drive lag bolt until mount is held firmly in place. <br /> WARRANTY <br /> ... NOTE:The EPDM in the sealing washer will expand beyond the edge of the metal washer when in <br /> CC <br /> Ilip <br /> proper torque is applied. I— <br /> Q N <br /> U w <br /> wU Q0) <br /> W W o � <br /> 20 oi= <br /> STEP 2: SEAL D (n cC w <br /> Insert tip of UNIRAC provided sealant into port.Inject until sealant exits both vents. CC W z Ct <br /> 1 , Continue array installation,attaching rails to mounts with provided T-bolts. z Ili <br /> 3 NOTE:When FLASHLOC is installed over gap between shingle or tabs or vertical joints, J <br /> �� fill gap/joint with sealant between mount and upslope edge of shingle course. <br /> 2 , z, <br /> Use only provided sealant. <br /> Cut Away View Cut Away View <br /> PROTECT THE ROOF LOC OUT WATER HIGH-SPEED INSTALL CITY OF EVERE Install a high-strength waterproof attachment With an outer shield III contour-conforming gasket n Simply drive lag bolt and inject sealant into the port 4 REVIEWED FOR. PERMIT <br /> without lifting.prying or damaging shingles. and pressurized sealant chamber©the Triple-loc Seal to create a permanent pressure seal. <br /> delivers a 100%waterproof connection. <br /> SHEET NAME <br /> EQUIPMENT <br /> FASTER INSTALLATION . 25 -YEAR WARRANTY. FASTER INSTALLATION . 25 -YEAR WARRANTY. SPESHET SIZE <br /> CIFICATION <br /> 1111 I III 11 111 11111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111 <br /> I II III III 1 1111111 11111111 II III 1111111111111111111111111111111111111111111111111111111111111111111111111 111111 II 1 Ilfll II I I <br /> 1111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111III1111111111{111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111111 1111111111111111111111111111111111111111111111111111111111IIIIIIIIIIIIIIIIII 111111111111111111 111111111111111 1 11 III III 1 11 1111 <br /> FOR QUESTIONS OR CUSTOMER SERVICE VISIT UNIRAC.COM OR CALL (505) 248-2702 FOR QUESTIONS OR CUSTOMER SERVICE VISIT UNIRAC.COM OR CALL (505) 248-2702 ANSI B <br /> 11" X17" <br /> SHEET NUMBER <br /> PV-14 <br />